Many taxidermist also degrease deer to achieve a more attractive skin. STEP-4 Degrease the skin of bears, boars and furbearers at this time. The thinning of these thick spots will allow the skin to more readily accept the tan. Thin down thick spots usually found on the forehead and back of neck. At this level bacteria can not grow so no additional bactericide is needed or necessary. MAINTAIN PH OF 2.Īlways maintain a PH of 2. Let skin soak overnight, agitate frequently and check PH. Raise Ph by adding water, lower by adding formic acid. Safety Acid may also be used.Ĭheck PH and adjust if necessary to a level of 2. Note: use hot water to dissolve the citric acid crystals. MixĢ0cc Formic Acid or 3 ounces of Citric acid per gallon Water. This step prepares the skin for the tan bath and sets the hair. STEP-2 Re-hydrate skin in a pickle solution. The next skin can be placed on top and let dry for 3 to 5 days. Let drain for 24 hours, open, shake off wet salt and re-salt. Roll the skin up with the head inside and place on a slanted board so the juices may drain out and away from the skin. Be very careful not to omit areas around the eyes and ears. Using non iodized salt, salt and rub into the flesh side of the skin. STEP-1 skin and remove all the fat and meat on the skin. PTS-Ph-Paper–Necessary to test PH of tanning baths. Many taxidermist use the new Lutan-F in place of Alum. PTS-Alum– A low iron aluminum sulfate used in the tanning bath. PH-Up should be used to raise the acidity level. PTS-PH-Up–The acidity of tanning baths must be monitored for best results. Results are the same, but you eliminate the hazards. PTS-Citric Acid–A much safer alternative to formic acid for the pickle bath. Protect your skin and eyes at all times and never put in a metal container. Formic acid should be treated with a great deal of care. PTS-Formic Acid–A strong corrosive material that is used in tanning formulas. Water must be 80 degrees for proper degreasing. Bears and most fur bearing animals must be degreased or the fur will be difficult to dry and fluff. PTS-Degreaser–Degreasing of certain skins is a requirement for good results. You want the skin to act like a sponge and suck the oil into the leather. After removing the cape from the alum bath, drain the skin and allow the flesh side to dry to a thirsty condition. The key to a properly oiled cape is the timing after the tanning bath and the oiling of the cape. Oil should be used at or slightly above room temperature. PTS-Tanning Oil-This is a professional quality tanning oil to be used on any cape or skin to be mounted. PROFESSIONAL QUALITY PRODUCTS-LOWER COST-MORE PROFIT Also individual results are determined by the individuals ability to shave or thin the skin, which is essential for good stretch in the finished product. We recommend that skins to be rugged, should be sent to a professional tanner due to the equipment necessary to properly finish dry tanned skins. The following steps should be followed for the tanning of capes and skins to be mounted. I have compiled step by step instructions for the use of these products. By purchasing these materials directly, we have been able to significantly reduce the cost to the taxidermist who wants to tan his own skins. With this system you will have the same quality as your present tan, but at a reduced cost of materials. With this in mind, we decided to look into the possibility of offering a line of the same products and procedures that professional tanners use. If you are following the basic tanning procedure of formic acid, salt and alum tan, then simply use professional tanning oils that are much cheaper than the products now being sold. The fact is that you are buying tanning oils and other products at a very inflated price. The directions for use of these products have changed and currently recommend the same steps as the basic tanning procedure that professional tanners have used for years. The bottom line is that these products did not work as stated and a multitude of problems developed. Instructions were to skin, salt and paint on these miracle tanning creams, let dry, re-soak and mount in the future. Initially these products were claimed to be a miracle short cut to the tanning process. Over the past several years there have been several tanning products introduced to the taxidermy market.
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |